texasfishingforum.com logo
Main Menu
Advertisement
Affiliates
Advertisement
Newest Members
TraeMartin, Power-Pole CS, T-Rigger, JoeGoes, EcKo
119150 Registered Users
Top Posters(All Time)
hopalong 120,590
TexDawg 119,532
Bigbob_FTW 94,913
John175☮ 85,893
Pilothawk 83,264
Bob Davis 81,534
Mark Perry 72,297
Derek 🐝 68,313
JDavis7873 67,416
Forum Statistics
Forums59
Topics1,037,875
Posts13,935,890
Members144,150
Most Online39,925
Dec 30th, 2023
Print Thread
Page 1 of 2 1 2
Skeeter ZX200 with VMAX SHO 200 hp ECU Flash report and results (long)... #12836834 07/21/18 10:02 PM
Joined: Jun 2016
Posts: 394
M
markson Online Content OP
Angler
OP Online Content
Angler
M
Joined: Jun 2016
Posts: 394
After finding out last year that the 200 hp SHO on my boat was a factory constrained
kitten needing to become a beast, I finally pulled the trigger and got my ECU flashed
to over 300 hp and the boat setup done by a couple of Pros. Here is a report of my
experiences and results so far.

ECU Flash by Steve at Hydro Dynamics (with stock rev limiter) - I emailed Steve my VMAX
SHO model year, model number and serial number. He sent that info to Nizpro in
Australia and they sent him the correct flash profile for my outboard. When I got to
his shop, Steve immediately removed my ECU, flashed it and reinstalled it, which only
took about 30 minutes. After the prop and boat setup was complete he followed me to the
ramp, helped my launch my boat, gave me some much needed pre-flight instructions and
then helped me load my boat when I returned. We spoke at length about my experiences
and results and what I should do next to get better performance and driving results.

Prop & Boat setup by Josh at Steve's Custom Props - After setting an appointment with
Steve for the ECU flash, I emailed Josh for his prop recommendation. He said he would
get one balanced and blueprinted for me and have it ready for install. After the flash
was done, Josh immediately removed my old prop and installed the new one with the
correct hub kit. Then we moved my boat to a level spot and he began setting the boat up
by measuring the prop to pad distance. After some quick calculations he determined that
the motor was WAY too high from the Factory and he started adjusting the jack plate to
lower the motor. I protested but he and Steve both explained to me how motor height
affects boat handling and performance, just one of the many lessons they would end up
teaching me. After my intial test, he reviewed my results and determined that the motor
needed to be raised slightly. While he adjusted the jack plate, he showed me the
process, the tools required and the performance goals we were seeking so I could
continue the tweaking on my own. Then he told me to keep him posted and he would change
the prop if needed to get the desired results once the boat was dialed in.

Both Steve and Josh were extremely forthcoming with me regarding the hows and whys of
everything they were doing and were very patient when dealing with my misperceptions
and plain wrong info I thought I knew about high speed boating. I got a crash course in
high performance setup and driving by a couple of real pros as well as exceptional
service and support. They both get my highest recommendation.

Set Up and Gear:
2016 Skeeter ZX200
2016 Yamaha VMAX SHO 200 (approx 200 hours)
ECU Flash by Steve at Hydro Dynamics (with stock rev limiter)
Mercury Tempest Plus prop, 27 pitch, B&B by Josh at Steve's Custom Props
Slidemaster manual jackplate at adjusted setting (2.5 dots)
One Power Pole, bow pedestal seat, no rear seat, Ultrex TM, tall RAM mounted
HDS 12 with Hydrowave mounted above HDS at bow (lots of air resistance)
Me, my dog, full ice chest & multi-day trip food at approx 350 lbs total
Full tournament tackle
Empty livewells
Full tank of gas (36 gallons)
3 Stock Interstate lead batteries
Previous speed and rpms were 66.3 - 68.7 at 6000 rmps and full trim

Conditions:
107 degree air temp
43% humidity
1012.9mb pressure and steady
Wind WSW @ 5 mph
87 degree water temp
Flat to slightly choppy water with very small rollers

Results:
Highest GPS Speed (tail wind)= 76.1 mph
Average GPS Speed = 73.5 - 75.5 mph depending on chop
Mid Range acceleration = estimated 2x to 3x quicker
RPM (analog) = 5800 average
Trim level - estimated at little over 3/4

I have yet to run at full trim and full rpms because of driving issues with me and with
the boat, engine height and conditions. On the first test runs the boat would get VERY
squirrley over 5800 rpms, even feeling like the stern wanted to whip around the bow
when I really pushed it. After Josh raised the engine for the second set of runs the
next day, the lake conditions were a lot worse with heavy weekend traffic and higher
winds / chop, but I could tell that the boat was much more stable over 73 mph and I
could hold the higher speeds longer with less driving. I will update this thread as I get
my setup dialed in, I hope it helps other SHO owners take the plunge to get all of the
performance they want from their rig.

Last edited by markson; 07/21/18 10:28 PM.
Re: Skeeter ZX200 with VMAX SHO 200 hp ECU Flash report and results (long)... [Re: markson] #12837180 07/22/18 04:02 AM
Joined: Sep 2013
Posts: 1,863
F
formula462 Offline
Extreme Angler
Offline
Extreme Angler
F
Joined: Sep 2013
Posts: 1,863
What is the cost per gain ratio?

Last edited by formula462; 07/22/18 04:51 AM.
Re: Skeeter ZX200 with VMAX SHO 200 hp ECU Flash report and results (long)... [Re: formula462] #12837229 07/22/18 06:43 AM
Joined: Jun 2016
Posts: 394
M
markson Online Content OP
Angler
OP Online Content
Angler
M
Joined: Jun 2016
Posts: 394
Originally Posted By: formula462
What is the cost per gain ratio?


The cost was $1140 for the flash, prop and boat setup. The actual cost per gain ratio is dependent on which variable you choose to use for the calculation (remember that I have yet to see the true top speed). To me the entire experience, education and future fun factor combine to make it priceless. Top speed notwithstanding, if my only gains had been just the midrange acceleration and increase in overall performance from the correct motor height, I would still consider it a great deal.

Re: Skeeter ZX200 with VMAX SHO 200 hp ECU Flash report and results (long)... [Re: markson] #12837291 07/22/18 12:23 PM
Joined: Jan 2005
Posts: 16,645
P
Pat Goff Online Content
TFF Guru
Online Content
TFF Guru
P
Joined: Jan 2005
Posts: 16,645
Thats very impressive.


Pat Goff
Seadrift TX
[Linked Image]
Re: Skeeter ZX200 with VMAX SHO 200 hp ECU Flash report and results (long)... [Re: markson] #12837635 07/22/18 06:15 PM
Joined: Aug 2009
Posts: 2,408
D
dimitri Online Content
Extreme Angler
Online Content
Extreme Angler
D
Joined: Aug 2009
Posts: 2,408
will fuel economy or warranty be effected? sounds like a great deal at that price and those mph gains .


Marine Electronics Installation
[by appointment only in Azle, Texas]
Graphs, Trolling Motors & Battery Chargers
Re: Skeeter ZX200 with VMAX SHO 200 hp ECU Flash report and results (long)... [Re: markson] #12837650 07/22/18 06:30 PM
Joined: May 2003
Posts: 11,586
gary purdy Offline
TFF Guru
Offline
TFF Guru
Joined: May 2003
Posts: 11,586
Very good results.


The world will not be destroyed by those who do evil, but by those who watch them without doing anything. Remember what He has done and remember that He is not done yet!-- GOD IS GOOD
Re: Skeeter ZX200 with VMAX SHO 200 hp ECU Flash report and results (long)... [Re: markson] #12837947 07/22/18 11:53 PM
Joined: Jun 2016
Posts: 394
M
markson Online Content OP
Angler
OP Online Content
Angler
M
Joined: Jun 2016
Posts: 394
Went out today after raising the plate another 1/8 inch (1/2 dot) to 3 dots high in an attempt to eliminate the last bit of driving issues at full trim. Filled the tank with 20 gallons of 93 octane to top it off to full (mixed with the 16 gallons of 89 left over from yesterday) and drove an hour to a lake with enough space for me to make quality test runs. I was able to find some great water that allowed me to fly the bow at full trim and full throttle for extended periods. Here are my results:

Conditions:
108 degree air temp
26% humidity
1012.9 mb pressure and falling
Wind SSW @ 8 mph
86.5 degree water temp
Flat to slightly choppy water with very minimal rollers

Results:
Highest GPS Speed (very slight tail wind) = 76.9 mph
Average GPS Speed = 75.8 - 76.5 mph depending on chop
Mid Range acceleration = estimated 2x to 3x quicker (no change from last runs)
RPM (analog) = 5950 - 6000
Trim level - Full

I do have one issue though, my jack plate is acting all kinds of stupid. Josh had a problem yesterday with it not moving level on both sides, so he tightened one side and leveled the other side. When I made my adjustment today it seemed to move level and I triple checked all of the bolts to make sure they were tight. When I checked it after the runs today, one side (the right) is a full dot higher than the other side. So I will be calling Steve tomorrow to see if he can help me figure this out.

Last edited by markson; 07/23/18 12:14 AM.
Re: Skeeter ZX200 with VMAX SHO 200 hp ECU Flash report and results (long)... [Re: markson] #12838166 07/23/18 02:18 AM
Joined: Jan 2006
Posts: 856
C
champRD Online Content
Pro Angler
Online Content
Pro Angler
C
Joined: Jan 2006
Posts: 856
That's really good in these temps. Fall temps you should be at 80 easily. Be careful, the speeds your at now stuff happens quick.

Re: Skeeter ZX200 with VMAX SHO 200 hp ECU Flash report and results (long)... [Re: markson] #12838945 07/23/18 07:08 PM
Joined: Aug 2006
Posts: 7,182
steve@S2Marine Offline
TFF Celebrity
Offline
TFF Celebrity
Joined: Aug 2006
Posts: 7,182
Thanks for the nice words man.. i enjoyed helping you get that boat running.


www.hydrodynamics-usa.com
info@hydrodynamics-usa.com
903-763-5225
www.s2marine.com
s2marinesales@gmail.com
Blazer Boats, Gambler boats and Legend Craft Boats




Re: Skeeter ZX200 with VMAX SHO 200 hp ECU Flash report and results (long)... [Re: markson] #12839609 07/24/18 03:40 AM
Joined: Jun 2016
Posts: 394
M
markson Online Content OP
Angler
OP Online Content
Angler
M
Joined: Jun 2016
Posts: 394
After screwing around with that Slidemaster today and determining it is kind of a pain in the a** to adjust level by myself and also knowing that I am going to end up trying different props, combined with running some bigger water today and wishing I could have adjusted my engine height on the fly to compensate for my 19.5' boat, I am pulling the trigger on a Bob's Action Jack from Amazon with easy interest free monthly payments. I used to not understand the allure of tweaking a bass boat for speed and performance, but after the last few days experiences, I totally get it. I even caught a bunch of schooling fish today in the middle of the lake where I was making passes in a location I would have never gone by before, so the best of both worlds!

Re: Skeeter ZX200 with VMAX SHO 200 hp ECU Flash report and results (long)... [Re: markson] #12841203 07/25/18 02:36 PM
Joined: Nov 2010
Posts: 9,472
Jake Shannon(Skeet4Life) Offline
TFF Celebrity
Offline
TFF Celebrity
Joined: Nov 2010
Posts: 9,472
cool thread!

Re: Skeeter ZX200 with VMAX SHO 200 hp ECU Flash report and results (long)... [Re: markson] #12841437 07/25/18 05:45 PM
Joined: Aug 2006
Posts: 7,182
steve@S2Marine Offline
TFF Celebrity
Offline
TFF Celebrity
Joined: Aug 2006
Posts: 7,182
let me give one piece of very important advice.
when dealing with FAST boats... the most dangerous thing one can do is... ADJUST ON THE FLY!!!

One bump to much and your gonna be in serious trouble.!!!!!

i see this all the time..... to go faster.. people think.. raise the plate. NEGATIVE.. that'll get you killed
in high performance boats.. over 75 .. and stuff happens really fast.

please be careful when raising the jack plate.. i'd highly recommend.. slowing down to around 45-50 then bump the plate a little .. then accelerate again.

be safe Mark.. let me know if i can help you with anything further.


www.hydrodynamics-usa.com
info@hydrodynamics-usa.com
903-763-5225
www.s2marine.com
s2marinesales@gmail.com
Blazer Boats, Gambler boats and Legend Craft Boats




Re: Skeeter ZX200 with VMAX SHO 200 hp ECU Flash report and results (long)... [Re: markson] #12841613 07/25/18 07:54 PM
Joined: Apr 2015
Posts: 1,818
Curtbass Offline
Extreme Angler
Offline
Extreme Angler
Joined: Apr 2015
Posts: 1,818
Steve, Thank you for posting that statement!!!!
Crabbing is NOT good.
Things DO happen quick!! Faster than humans can react.

markson, Thanks for the setup/run out info. Great post. Keep updating as you upgrade to get the benefits out of it all. Stay Safe.
Enjoy your new setup to the utmost.
We all admit , it IS an adrenaline rush like no other!!!


ELITE POWER SYSTEMS/ Elite Fishing Products
Lithium Battery & Charging Systems, Soft Plastics, Tackle,Tokyo Rigs
Tight lines & stay safe out there.Gods blessings
Re: Skeeter ZX200 with VMAX SHO 200 hp ECU Flash report and results (long)... [Re: markson] #12841665 07/25/18 08:27 PM
Joined: Jan 2005
Posts: 16,645
P
Pat Goff Online Content
TFF Guru
Online Content
TFF Guru
P
Joined: Jan 2005
Posts: 16,645
Steve is correct.
Take it from someone whos been slung out of a few boats.
When you start getting over 75 very small moves make big differences


Pat Goff
Seadrift TX
[Linked Image]
Re: Skeeter ZX200 with VMAX SHO 200 hp ECU Flash report and results (long)... [Re: markson] #12841696 07/25/18 08:44 PM
Joined: Apr 2017
Posts: 11,977
tmd11111 Online Content
TFF Guru
Online Content
TFF Guru
Joined: Apr 2017
Posts: 11,977
Oh I remember getting that bug years ago. Faster, faster, Faster. Wallet started running dry when I hit 90 mph.

Page 1 of 2 1 2
Previous Thread
Index
Next Thread

© 1998-2022 OUTDOOR SITES NETWORK all rights reserved USA and Worldwide
Powered by UBB.threads™ PHP Forum Software 7.7.3