Texas Fishing Forum

Possible reed issue

Posted By: sliding by

Possible reed issue - 08/14/19 11:32 PM

I have a 1999 Mercury 75hp two stroke. It is running rough at low throttle and is sluggish getting out of the hole. Half to full throttle runs great. Pulled the air cover off and there was gas/oil on the inside of the cover and a little bit pooled in the bottom. Pulled the carbs and noticed that there was gas dripping from the underside of the bottom manifold. Pulled the manifold off and pushed on the reeds (didn’t have replacement gaskets to pull the reed body) Looks like one reed does not spring back as strong as the other ones. I know that a broke reed will cause issues but will a weaker reed do the same. Can I just replace the set of three with the week reed or do I have to change all nine reeds? Am I on the right path here. Sorry for the long post.
Posted By: boatman025

Re: Possible reed issue - 08/15/19 01:17 PM

Yes only way to get then and also replace all gasket,
Posted By: T Bird

Re: Possible reed issue - 08/15/19 01:19 PM

Sounds like a good troubleshooting plan.Weak reeds can cause same issues. I'd change all reeds. Good possibility that one or more may be chipped/broken.
Posted By: sliding by

Re: Possible reed issue - 08/15/19 01:42 PM

Thanks for the responses. Hoping it’s just a weak reed. Really don’t want to have to tear it down to find a missing piece.
Posted By: T Bird

Re: Possible reed issue - 08/15/19 02:45 PM

Originally Posted by sliding by
Thanks for the responses. Hoping it’s just a weak reed. Really don’t want to have to tear it down to find a missing piece.


If you have chipped reeds, pieces will have blown out exhaust. No worries there.
Posted By: Matt M

Re: Possible reed issue - 08/19/19 02:49 AM

Call Chris Carson marine In FL and see if he builds a reed set for your Motor
© 2024 Texas Fishing Forum