Main Menu
Advertisement
Affiliates
Advertisement
Newest Members
jwhit88, Fisherman954, Mud Liger, Joe111, EL Mike
102702 Registered Users
Top Posters
TexDawg 82849
hopalong 74375
Pilothawk 73411
JDavis7873® 67377
FattyMcButterpants 60518
John175 ® 59859
Tritonman 56817
Derek 56400
SkeeterRonnie 52450
LoneStarSon® 52211
facebook
Forum Stats
102702 Members
61 Forums
858760 Topics
11265515 Posts

Max Online: 36273 @ 01/23/13 02:34 PM
Topic Options
#10820764 - 05/05/15 04:13 PM Mercury optimax
Caught1 Offline
Outdoorsman

Registered: 08/03/08
Posts: 221
Loc: Flint, Tx
I have a 2009 Mercury 150 Optimax that just had the TPS replaced.Second trip out, 4 beeps went off and continue even when water and oil level sensors are unplugged. No water found in seperator and oil is full. The beeps are 2 minutes apart. Mechanic says he is about 3 weeks till he can get to it. Any thoughts on what it could be?

Top
#10821007 - 05/05/15 06:04 PM Re: Mercury optimax [Re: Caught1]
hopalong Online   content
Super Freak

Registered: 09/06/08
Posts: 74375
Loc: manager, drake river ranch (fo...
Re: Trouble codes/beeps (SPRINT 290DC)
Well, you're in luck.... I just happen to be sitting here on the porch studying an EFI Course Technician's Guide right now....

LOW OIL LEVEL: The low oil level warning is activate when the remaining oil in the mounted oil resevoir tank drops below 50 fl. oz.... WARNING HORN EMITS A SERIES OF FOUR BEEPS.

ENGINE OVERHEAT: HORN SOUNDS CONTINUOUSLY

ENGINE OVERSPEED: INTERMITTENT BEEP until engine speed drops below MAXIMUM RPM.

ELECTRICAL SENSOR NOT FUNCTIONING: If the TPS, MAP, or CTS is not functioning, or is out of it's "pre-programmed diagnostic range", the warning horn will sound INTERMITTENTLY.

WATER IN FUEL WARNING: SERIES OF FOUR BEEPS.

These warnings were intended to be utilized with a "WARNING LIGHT GAUGE" (which provided additional information via lighted warning lights).


stolen from the bbc boards
_________________________
Tallgrass05 on 11/8/16 at 3:32 PM
The GOP declared Hillary the winner when they picked Trump as their candidate months ago.

FISHERMANS COVE MARINA - 903 474 7479 reservations

Top
#10821209 - 05/05/15 07:29 PM Re: Mercury optimax [Re: Caught1]
Allison1 Online   sleepy
TFF Guru

Registered: 12/14/03
Posts: 16311
Loc: Grand Prairie, Tx
4 beeps is either low oil in the remote tank or water in the onboard filter. Third thing it could be is a low battery. First if your oil is not to the top it will set off the alarm. Simple fix if thats it. Loosen the cap. Run the motor and the tank will slowly fill. When its full tighten the cap.
If thats not it plug the water sensor back in and test the oil sensor.
Unhooking the harness only means the alarms will go off. Unhooked (open) equals alarm. Short out the leads once you unplug it and if the alarm goes away replace the sender.



Top
#10830160 - 05/09/15 08:01 AM Re: Mercury optimax [Re: Caught1]
Randy Harrell Offline
Extreme Angler

Registered: 03/30/10
Posts: 1427
Loc: Winnsboro, Tx
I had the same beeps on my 06 Opti.

Here is the link to my posts then.
http://texasfishingforum.com/forums/ubbthreads.php/topics/8969547/Optimax_Alarm#Post8969547

Most likely will need a new oil tank. I don't know of any way to change the sensor. They run around $100.00. It is not a hard job other than 1 bolt is hard to get to.


_________________________
Set the hook first, ask questions later.

Winnsboro High School Boat Captain

Top



© 1998-2016 OUTDOOR SITES NETWORK all rights reserved USA and Worldwide